Flyback Mode for Improved Low-Power Efficiency in the Dual-Active-Bridge Converter for Bidirectional PV Microinverters With Integrated Storage

This paper targets photovoltaic microinverters (MIVs) with integrated battery storage. The dual-active-bridge (DAB) topology provides bidirectional power flow; however, it generally suffers from poor efficiency and limited regulation accuracy at low power. It is shown that by modifying one switch, the DAB converter can operate as a two-transistor flyback to resolve these two issues. In addition, the dc-link voltage in the two-stage MIV can be dynamically adjusted for optimal performance in DAB mode. The proposed dual-mode control scheme is demonstrated experimentally on a 100-W prototype, with up to 8% increase in converter efficiency at low power.

[1]  Marcelo Gustavo Molina,et al.  Improving the Integration of Wind Power Generation Into AC Microgrids Using Flywheel Energy Storage , 2012, IEEE Transactions on Smart Grid.

[2]  Olivier Trescases,et al.  A dual active bridge DC-DC converter with optimal DC-link voltage scaling and flyback mode for enhanced low-power operation in hybrid PV/storage systems , 2014, 2014 International Power Electronics Conference (IPEC-Hiroshima 2014 - ECCE ASIA).

[3]  F. Blaabjerg,et al.  A review of single-phase grid-connected inverters for photovoltaic modules , 2005, IEEE Transactions on Industry Applications.

[4]  O. Trescases,et al.  A General Approach for Quantifying the Benefit of Distributed Power Electronics for Fine Grained MPPT in Photovoltaic Applications Using 3-D Modeling , 2012, IEEE Transactions on Power Electronics.

[5]  Marian K. Kazimierczuk,et al.  Two-switch flyback-forward PWM DC-DC converter with reduced switch voltage stress , 2010, Proceedings of 2010 IEEE International Symposium on Circuits and Systems.

[6]  Olivier Trescases,et al.  A dual-active-bridge based bi-directional micro-inverter with integrated short-term Li-Ion ultra-capacitor storage and active power smoothing for modular PV systems , 2014, 2014 IEEE Applied Power Electronics Conference and Exposition - APEC 2014.

[7]  K. M. Muttaqi,et al.  Mitigation of Rooftop Solar PV Impacts and Evening Peak Support by Managing Available Capacity of Distributed Energy Storage Systems , 2013, IEEE Transactions on Power Systems.

[8]  R. A. Cabraal.  Experiences and lessons from 15 years of World Bank support for photovoltaics for off-grid electrification , 2012, 2nd International Conference on the Developments in Renewable Energy Technology (ICDRET 2012).

[9]  Murali Munraj.  Digitally Controlled Current-Mode Dc-Dc Converter Ic , 2012 .

[10]  Massimo Vitelli,et al.  Distributed maximum power point tracking of photovoltaic arrays: Novel approach and system analysis , 2008, IEEE Transactions on Industrial Electronics.

[11]  D.D.-C. Lu,et al.  A Single-Stage AC/DC Converter With High Power Factor, Regulated Bus Voltage, and Output Voltage , 2008, IEEE Transactions on Power Electronics.

[12]  Hui Li,et al.  An Integrated Three-Port Bidirectional DC–DC Converter for PV Application on a DC Distribution System , 2013, IEEE Transactions on Power Electronics.

[13]  German G. Oggier,et al.  High efficiency switching sequence and enhanced dynamic regulation for DAB converters in solid-state transformers , 2014, 2014 IEEE Applied Power Electronics Conference and Exposition - APEC 2014.

[14]  Minwon Park,et al.  A study on the optimal voltage for MPPT obtained by surface temperature of solar cell , 2004, 30th Annual Conference of IEEE Industrial Electronics Society, 2004. IECON 2004.

[15]  Hengsi Qin,et al.  Generalized Average Modeling of Dual Active Bridge DC–DC Converter , 2012, IEEE Transactions on Power Electronics.

[16]  P. Mattavelli,et al.  Prediction of limit-cycles oscillations in digitally controlled DC-DC converters using statistical approach , 2005, 31st Annual Conference of IEEE Industrial Electronics Society, 2005. IECON 2005..

[17]  Abdul Ahad,et al.  AN INTEGRATED BOOST RESONANT CONVERTER FOR PHOTOVOLTAIC APPLICATIONS , 2014 .

[18]  Zheng Zhao,et al.  High efficiency wide load range buck/boost/bridge photovoltaic microconverter , 2011, 2011 Twenty-Sixth Annual IEEE Applied Power Electronics Conference and Exposition (APEC).

[19]  Robert W. Erickson,et al.  A Microinverter for Building-Integrated Photovoltaics , 2009, 2009 Twenty-Fourth Annual IEEE Applied Power Electronics Conference and Exposition.

[20]  Haibing Hu,et al.  A Single-Stage Microinverter Without Using Eletrolytic Capacitors , 2013, IEEE Transactions on Power Electronics.

[21]  J. Kolar,et al.  Integration of Leakage Inductance in Tape Wound Core Transformers for Dual Active Bridge Converters , 2012, 2012 7th International Conference on Integrated Power Electronics Systems (CIPS).

[22]  Malik Elbuluk,et al.  Fundamentals of Power Electronics , 2013 .

[23]  Alex Q. Huang,et al.  A High Step-Up Three-Port DC–DC Converter for Stand-Alone PV/Battery Power Systems , 2013, IEEE Transactions on Power Electronics.

[24]  Alberto Rodriguez,et al.  Different purpose design strategies and techniques to improve the performance of a Dual Active Bridge with phase-shift control , 2014, 2014 IEEE 15th Workshop on Control and Modeling for Power Electronics (COMPEL).

[25]  R. D. De Doncker,et al.  Calculation of losses in ferro- and ferrimagnetic materials based on the modified Steinmetz equation , 1999, Conference Record of the 1999 IEEE Industry Applications Conference. Thirty-Forth IAS Annual Meeting (Cat. No.99CH36370).

[26]  Hui Li,et al.  A Cascaded Photovoltaic System Integrating Segmented Energy Storages With Self-Regulating Power Allocation Control and Wide Range Reactive Power Compensation , 2011, IEEE Transactions on Power Electronics.

[27]  Dong Chen,et al.  Control and Operation of a DC Microgrid With Variable Generation and Energy Storage , 2011, IEEE Transactions on Power Delivery.

[28]  Johann W. Kolar,et al.  Efficiency-Optimized High-Current Dual Active Bridge Converter for Automotive Applications , 2012, IEEE Transactions on Industrial Electronics.