Controllability Analysis of Two-phase Pipeline-riser Systems at Riser Slugging Conditions

Abstract A PDE-based two-fluid model is used to investigate the controllability properties of a typical pipeline-riser system. Analysis of the model reveals a very interesting and challenging control problem, with the presence of both unstable poles and unstable zeros. It is confirmed theoretically that riser slugging in pipeline-riser systems can be avoided with a simple control system that manipulate the valve at the top of the riser. The type and location of the measurement to the controller is critical. A pressure measurement located upstream of the riser (that is, at the riser base or pipeline inlet) is a good candidate for stabilizing control. On the other hand, a pressure measurements located at the top of the riser cannot be used for stabilizing control because of unstable zero dynamics. A flow measurement located at the top of the riser can be used to stabilize the process, but, because the steady state gain is close to zero, it should in practice only be used in an inner control loop in a cascade.

[1]  John-Morten Godhavn,et al.  New slug control strategies, tuning rules and experimental results , 2005 .

[2]  Yehuda Taitel,et al.  STABILITY OF SEVERE SLUGGING , 1986 .

[3]  Espen Storkaas.  Stabilizing control and controllability. Control solutions to avoid slug flow in pipeline-riser systems , 2005 .

[4]  Randi Moe,et al.  The dynamic two-fluid model OLGA; Theory and application , 1991 .

[5]  K. Aziz,et al.  A flow pattern map for gas—liquid flow in horizontal pipes , 1974 .

[6]  S. Patankar.  Numerical Heat Transfer and Fluid Flow , 2018, Lecture Notes in Mechanical Engineering.

[7]  K. Havre,et al.  Limitations imposed by RHP zeros/poles in multivariable systems , 1997, 1997 European Control Conference (ECC).

[8]  Sigurd Skogestad,et al.  Selection of variables for stabilizing control using pole vectors , 2003, IEEE Trans. Autom. Control..

[9]  R. Sachdeva,et al.  Two-Phase Flow Through Chokes , 1986 .

[10]  Jie Chen,et al.  Logarithmic integrals, interpolation bounds, and performance limitations in MIMO feedback systems , 2000, IEEE Trans. Autom. Control..

[11]  Manfred Morari,et al.  Design of resilient processing plants. VI: The effect of right-half-plane zeros on dynamic resilience , 1985 .

[12]  Thomas Bewley,et al.  Flow control: new challenges for a new Renaissance , 2001 .

[13]  Dvora Barnea,et al.  A unified model for predicting flow-pattern transitions for the whole range of pipe inclinations , 1987 .

[14]  B. Kendall.  Nonlinear Dynamics and Chaos , 2001 .

[15]  A. Dukler,et al.  A model for predicting flow regime transitions in horizontal and near horizontal gas‐liquid flow , 1976 .

[16]  Tarek Ahmed,et al.  6 – Flow Assurance , 2007 .

[17]  Kietil Havre,et al.  Taming slug flow in pipelines , 2000 .

[18]  K. Glover.  Robust stabilization of linear multivariable systems: relations to approximation , 1986 .

[19]  Sigurd Skogestad,et al.  Achievable performance of multivariable systems with unstable zeros and poles , 2001 .

[20]  Steven H. Strogatz,et al.  Nonlinear Dynamics and Chaos , 2024 .

[21]  A. Courbot.  Prevention of Severe Slugging in the Dunbar 16' Multiphase Pipeline , 1996 .

[22]  Cem Sarica,et al.  A New Technique to Eliminate Severe Slugging in Pipeline/Riser Systems , 2000 .

[23]  K. Kovalev,et al.  The Slug Suppression System in Operation , 2003 .

[24]  A..  Prevention of Severe Slugging in the Dunbar 16 “ Multiphase Pic ) eline , 1997 .

[25]  Eric Heintze,et al.  Simulation of Process to Control Severe Slugging: Application to the Dunbar Pipeline , 1999 .

[26]  Kjetil Havre,et al.  Active Feedback Control as a Solution to Severe Slugging , 2002 .

[27]  Erich Zakarian.  ANALYSIS OF TWO-PHASE FLOW INSTABILITIES IN PIPE-RISER SYSTEMS , 2000 .

[28]  J. Weisman,et al.  Effects of fluid properties and pipe diameter on two-phase flow patterns in horizontal lines , 1979 .

[29]  Yehuda Taitel,et al.  Two-Phase Slug Flow , 1990 .

[30]  A. E. Dukler,et al.  Modelling flow pattern transitions for steady upward gas‐liquid flow in vertical tubes , 1980 .