Quasi-Parallel Voltage Regulator Topology for Powering Laptop Processors

This paper presents a quasi-parallel voltage regulator topology that is suitable as a laptop processor power supply where the input voltage varies over a wide range. It consists of a phase shift full bridge converter and a buck converter, whose inputs are connected in series to divide the total input voltage and the outputs are connected in parallel to share the load current. The output voltage is regulated with fast dynamics against load change and input voltage variation while the input voltage to the buck converter is also regulated at a relatively low value to improve the overall system efficiency. Different methods to improve the converter efficiency further at both light and high loads are also proposed. The efficiency of the converter at different load currents and input voltages are obtained from a laboratory prototype demonstrating a maximum efficiency of 90.8% at an output voltage of 1.2 V. A small signal model of the converter is then presented and a design methodology for a decoupled controller is discussed. Transient performance of the converter using this controller against 50 A load current change is found to comply with the specifications for a laptop processor power supply.

[1]  Sheng Ye,et al.  A Novel Non-Isolated Full Bridge Topology for VRM Applications , 2007, APEC 07 - Twenty-Second Annual IEEE Applied Power Electronics Conference and Exposition.

[2]  Liyu Cao,et al.  Small Signal Modeling for Phase-shifted PWM Converters with A Current Doubler Rectifier , 2007, 2007 IEEE Power Electronics Specialists Conference.

[3]  N. H. Kutkut.  A full bridge soft switched telecom power supply with a current doubler rectifier , 1997, Proceedings of Power and Energy Systems in Converging Markets.

[4]  K. I. Hwu,et al.  Improvement in Efficiency of the Phase-shift Current-doubler-rectification ZVS Full-bridge DC-DC Converter , 2007, APEC 07 - Twenty-Second Annual IEEE Applied Power Electronics Conference and Exposition.

[5]  Julu Sun,et al.  Investigation of Alternative Power Architectures for CPU Voltage Regulators , 2008 .

[6]  Xinbo Ruan,et al.  A Family of Switching Capacitor Regulators , 2014, IEEE Transactions on Power Electronics.

[7]  Dan Chen,et al.  Modeling and Design for a Novel Adaptive Voltage Positioning (AVP) Scheme for Multiphase VRMs , 2008, IEEE Transactions on Power Electronics.

[8]  F.C. Lee,et al.  A Switching-Capacitor PWM DC–DC Converter and Its Variations , 2010, IEEE Transactions on Power Electronics.

[9]  Fred C. Lee,et al.  Integrated Magnetic Self-Driven ZVS Nonisolated Full-Bridge Converter , 2010, IEEE Transactions on Industrial Electronics.

[10]  K. Nishijima,et al.  A two-phase high step down coupled-inductor converter for next generation low voltage CPU , 2011, 8th International Conference on Power Electronics - ECCE Asia.

[11]  F.C. Lee,et al.  High efficiency quasi-parallel Voltage Regulators , 2008, 2008 Twenty-Third Annual IEEE Applied Power Electronics Conference and Exposition.

[12]  Peng Xu,et al.  Critical inductance in voltage regulator modules , 2002, APEC. Seventeenth Annual IEEE Applied Power Electronics Conference and Exposition (Cat. No.02CH37335).

[13]  N. H. Kutkut,et al.  Current mode control of a full bridge DC-to-DC converter with a two inductor rectifier , 1997, PESC97. Record 28th Annual IEEE Power Electronics Specialists Conference. Formerly Power Conditioning Specialists Conference 1970-71. Power Processing and Electronic Specialists Conference 1972.

[14]  F.C. Lee,et al.  Two-stage approach for 12-V VR , 2004, IEEE Transactions on Power Electronics.

[15]  Xinbo Ruan,et al.  Non-isolated flyback switching capacitor voltage regulator , 2011, 2011 IEEE Energy Conversion Congress and Exposition.

[16]  F.C. Lee,et al.  Voltage divider and its application in the two-stage power architecture , 2006, Twenty-First Annual IEEE Applied Power Electronics Conference and Exposition, 2006. APEC '06..

[17]  Amit Patra,et al.  A Cascade Point of Load DC–DC Converter With a Novel Phase Shifted Switched Capacitor Converter Output Stage , 2016, IEEE Transactions on Power Electronics.

[18]  Xinbo Ruan,et al.  Nonisolated Flyback Switching Capacitor Voltage Regulator , 2013, IEEE Transactions on Power Electronics.

[19]  Yuancheng Ren,et al.  High Frequency, High Efficiency Two-Stage Approach for Future Microprocessors , 2005 .

[20]  Zhiliang Zhang,et al.  A 1-MHz, 12-V ZVS Nonisolated Full-Bridge VRM With Gate Energy Recovery , 2010, IEEE Transactions on Power Electronics.

[21]  Graham C. Goodwin,et al.  Control System Design , 2000 .

[22]  Kai Sun,et al.  A High Step-Down Multiple Output Converter With Wide Input Voltage Range Based on Quasi Two-Stage Architecture and Dual-Output LLC Resonant Converter , 2015, IEEE Transactions on Power Electronics.

[23]  F.C. Lee,et al.  Two-stage voltage regulator for laptop computer CPUs and the corresponding advanced control schemes to improve light-load performance , 2004, Nineteenth Annual IEEE Applied Power Electronics Conference and Exposition, 2004. APEC '04..

[24]  Yehui Han,et al.  Quasi-parallel switched-capacitor and regulating PWM DC-DC converter , 2014, 2014 IEEE Applied Power Electronics Conference and Exposition - APEC 2014.

[25]  Yan-Fei Liu,et al.  A Nonisolated ZVS Asymmetrical Buck Voltage Regulator Module With Direct Energy Transfer , 2009, IEEE Transactions on Industrial Electronics.

[26]  Robert W. Erickson,et al.  Fundamentals of Power Electronics , 2001 .

[27]  F.C. Lee,et al.  A self-driven soft-switching voltage regulator for future microprocessors , 2005, IEEE Transactions on Power Electronics.